Gravity separation of fat, somatic cells, and bacteria in raw and pasteurized milks
- 1 April 2013
- journal article
- research article
- Published by American Dairy Science Association in Journal of Dairy Science
- Vol. 96 (4), 2011-2019
- https://doi.org/10.3168/jds.2012-6006
Abstract
The objective of experiment 1 was to determine if the extent of gravity separation of milk fat, bacteria, and somatic cells is influenced by the time and temperature of gravity separation or the level of contaminating bacteria present in the raw milk. The objective of experiment 2 was to determine if different temperatures of milk heat treatment affected the gravity separation of milk fat, bacteria, and somatic cells. In raw milk, fat, bacteria, and somatic cells rose to the top of columns during gravity separation. About 50 to 80% of the fat and bacteria were present in the top 8% of the milk after gravity separation of raw milk. Gravity separation for 7 h at 12 degrees C or for 22 h at 4 degrees C produced equivalent separation of fat, bacteria, and somatic cells. The completeness of gravity separation of fat was influenced by the level of bacteria in the milk before separation. Milk with a high bacterial count had less (about 50 to 55%) gravity separation of fat than milk with low bacteria count (about 80%) in 22 h at 4 degrees C. Gravity separation caused fat, bacteria, and somatic cells to rise to the top of columns for raw whole milk and high temperature, short-time pasteurized (72.6 degrees C, 25 s) whole milk. Pasteurization at >= 76.9 degrees C for 25 s prevented all 3 components from rising, possibly due to denaturation of native bovine immunoglobulins that normally associate with fat, bacteria, and somatic cells during gravity separation. Gravity separation can be used to produce reduced-fat milk with decreased bacterial and somatic cell counts, and may be a critical factor in the history of safe and unique traditional Italian hard cheeses produced from gravity-separated raw milk. A better understanding of the mechanism of this natural process could lead to the development of new nonthermal thermal technology (that does not involve heating the milk to high temperatures) to remove bacteria and spores from milk or other liquids.Keywords
This publication has 13 references indexed in Scilit:
- Diversity of cheese varieties: An overviewPublished by Elsevier ,2004
- Milk pH as a Function of CO2 Concentration, Temperature, and Pressure in a Heat ExchangerJournal of Dairy Science, 2003
- Milk immunoglobulins and complement factorsBritish Journal of Nutrition, 2000
- Gravity Separation of Raw Bovine Milk: Fat Globule Size Distribution and Fat Content of Milk FractionsJournal of Dairy Science, 2000
- Stability of bovine immunoglobulins to thermal treatment and processingFood Research International, 1995
- Microbiological Safety of Cheese Made from Heat-Treated Milk, Part III. Technology, Discussion, Recommendations, BibliographyJournal of Food Protection, 1990
- Microbiological Safety of Cheese Made from Heat-Treated Milk, Part II. MicrobiologyJournal of Food Protection, 1990
- Microbiological Safety of Cheese Made from Heat-Treated Milk, Part I. Executive Summary, Introduction and HistoryJournal of Food Protection, 1990
- The association of extrinsic bovine IgG1, IgG2, SIgA and IgM with the major fractions and cells of milkVeterinary Immunology and Immunopathology, 1986
- Reexamination of Fat Globule Clustering and Creaming in Cow MilkJournal of Dairy Science, 1984